Specifications and Parts:
- Hydraulic Tank Approx. 9.5 US Gallons (35.85 Liters)
- Engine - 14HP Subaru with oil alert
- Engine Crankcase oil - 1.25 Quarts (1.2 Liters)
- Gas Tank 1.85 US Gallons
- Gas - Fresh 86 Octane or Higher
- Hydraulic Pump - Gear type
- Valve - Spool type with pressure adjustable override
- 4000 PSI mix and discharge hose
- 2250 PSI Low pressure return hose
- Pump to valve hose 3500 PSI
- Valve to filter hose 2250 PSI
- Hydraulic oil filter and base
- 2" Suction strainer (100 mesh screen)
- 2" Vented hydraulic oil cap
- Oil temperature gauge 0-200 degrees
- Hydraulic pressure gauge filled 0-5000 PSI
Disclaimer
Once concrete hydration has started the Drum Jumped must be hooked up and operating before the concrete achieves initial set and becomes on mass. The before and after of initial set is a fine line.
Therefore, RSW Companies, LLC, can assume no liability for concrete quality, concrete set up in the mixer drum, damage to equipment or property while using the Drum Jumper.
RSW Companies, LLC disclaims any express or implied warranties except as mentioned in warranty paragraph. Additionally, RSW Companies, LLC assume no liability for use of its product. RSW Companies, LLC provides a set of instructions with its product and assumes purchase uses in conformance with the instructions.
The Drum Jumper Will:
- Allow you to mix water and/or retarder into the concrete.
- Agitate the concrete until repairs can be made.
- Continue to agitate the concrete while the ready mix truck is being towed.
- Unload the concrete and SAVE YOUR DRUM!
The Drum Jumper Will Not:
- Turn loads exceeding 2750 PSI reading on the truck slump meter.
- Break loads loose that are set up.
WARNING: You may damage the drum jumper, mixer hydraulic drive motor and/or mixer gear box trying to do so. - In extreme hot weather and/or high pump pressures run extended periods of time without hydraulic oil overheating.
- Turn your drum if the hydraulic drive motor is weak or bad.
- Turn your drum if the mixer gearbox is damaged.
